Quick answer
When the Geely Tugella A/C stops cooling properly, possible causes include a refrigerant leak, a compressor that is not engaging or pumping, a condenser that is dirty or damaged, a sticking expansion valve, or weak airflow from the blower or a clogged cabin filter. The coupe-SUV shape, with a sloping roof and rear glass, can let a lot of sun into the cabin, so a small loss of A/C capacity is felt quickly. Geely UAE publishes no A/C data for the Tugella, so parts are matched by VIN.
What this page covers for the Tugella
| Covered | Not verified by ShipMyPart |
|---|---|
| Tugella coupe SUV listed by Geely UAE | Model year |
| 2.0TD turbo petrol, 8AT, 4WD | Refrigerant type and amount |
| Wheelbase 2,700 mm | Compressor design and climate-control layout by trim |
A/C components are matched to each car through its VIN.
Specifications
| Item | Value | Source |
|---|---|---|
| Model on Geely UAE | Tugella (coupe SUV) | www.geely.ae |
| Engine | 2.0TD turbocharged petrol | www.geely.ae |
| Power / torque | 175 kW (238 HP) / 350 N·m | www.geely.ae |
| Transmission | 8-speed automatic (8AT) | www.geely.ae |
| Drive | Four-wheel drive (4WD) | www.geely.ae |
| Wheelbase | 2,700 mm | www.geely.ae |
Fluid specifications for this model are confirmed by VIN on request.
What Tugella owners notice
- On a hot afternoon the vents give lukewarm or slightly cool air, never properly cold air.
- The A/C cools on the motorway but fades in queues or at drive-throughs.
- Cooling cuts in and out, sometimes with a click from the engine bay.
- The fan is noisy, or some fan speeds do not work.
- There is a damp smell or water on the passenger floor.
- The rear of the cabin stays warm under the sloping rear window.
Possible causes and the clue that hints at each
| Possible cause | Typical clue |
|---|---|
| Refrigerant leak at a hose or joint | Cooling has faded gradually over weeks |
| Compressor not engaging or worn | No change at all when the A/C is switched on, or noise from the engine bay |
| Condenser blocked or damaged | Good while moving, poor when stationary |
| Expansion valve sticking | Cooling erratic, sometimes frosting |
| Pressure switch or sensor fault | Compressor cycles on and off quickly |
| Blower motor or its control | Weak or missing airflow on some speeds |
| Cabin air filter clogged | Airflow weak even though the air is cold |
| Evaporator leak or blocked drain | Musty smell or wet carpet |
Clues narrow things down, but only a workshop pressure and leak test can confirm a cause.
A/C components we can source for the Tugella
| Part of the circuit | Parts |
|---|---|
| High-pressure side (front of the car) | A/C compressor, condenser, pressure switch |
| Expansion and cooling (behind the dash) | Expansion valve, evaporator |
| Connections | Refrigerant hoses |
| Cabin airflow | Blower motor, cabin air filter |
No price is sent for any of these until the part has been matched to your VIN.
Owner checks without tools
- Start with recirculation on and the coldest setting, and note how long the cabin takes to feel comfortable.
- Compare cooling at idle and while driving.
- Test every fan speed and every vent direction.
- Look at the condenser through the lower grille for debris or damage from stones.
- Check the passenger footwell carpet for damp.
- Use a windscreen sunshade when parked; if the A/C copes much better afterwards, the system may be marginal rather than failed.
Never loosen A/C connections yourself; the circuit is pressurised and refrigerant work needs workshop equipment.
Workshop diagnosis and safety
| Book an A/C diagnosis when… | Pull over and switch off when… |
|---|---|
| cooling has faded over weeks or cuts in and out | a burning smell comes from the engine bay |
| the compressor seems never to engage | smoke appears from under the bonnet |
| there is oily residue on A/C pipes or a wet footwell | grinding is followed by dashboard warnings |
A proper check at a qualified workshop with A/C equipment reads both system pressures, traces leaks with dye or an electronic detector, and confirms that the climate control is commanding the compressor. A gas top-up without a repaired leak only helps for a short time.
Why heat builds up in a Tugella cabin
The Tugella's coupe styling gives it a sloping roofline and a steeply raked rear window, so the rear of the cabin catches a lot of direct sun when parked outdoors in a UAE summer. Dark interiors and long waits at traffic lights add to the load on the A/C. Dust storms coat the condenser and fill the cabin filter, and owners who take the four-wheel drive onto sand tend to see this sooner. Small drops in A/C performance become obvious from May onwards.
Sourcing Tugella A/C parts
Send a photo of the registration card showing the VIN, plus the diagnosis. ShipMyPart matches the A/C component to your Tugella and prices it with UAE delivery. ShipMyPart can help source the correct replacement parts, while recharging and fitting are done by an A/C-equipped workshop. Other parts are listed on the Tugella spare parts hub.
Compatible products
Compatibility verification required
No part is listed here as compatible until it has been matched to your vehicle. Send your VIN and we will confirm which parts fit before you order.
Confirm by VIN before you order
Send your VIN (chassis number) and we will confirm the correct air-conditioning parts for your Geely Tugella.
Related Geely Tugella parts
More Geely Tugella guides
Frequently asked questions
Why is my Geely Tugella A/C not cold?
Possible causes include low refrigerant from a leak, a compressor fault, a dirty condenser, a sticking expansion valve or a pressure-switch fault. A workshop test confirms the cause.
Why does the Tugella A/C cool only while driving?
This can indicate a condenser that is not getting enough airflow at idle, for example because of debris or a cooling fan issue.
Why is the back of my Tugella cabin hotter?
The sloping rear glass lets in a lot of sun. If the rear stays hot even after a long drive, weak airflow or a low charge may be the cause.
Is it safe to use an A/C recharge can on the Tugella?
It is not recommended. Find and repair the leak first; refrigerant should be handled with workshop equipment.
Which refrigerant does the Tugella use?
Geely UAE does not publish it and ShipMyPart has not verified it. The workshop or the label under the bonnet can confirm it.
Can ShipMyPart supply a Tugella A/C compressor?
Yes. Send the VIN and we match the compressor and quote with UAE delivery.
Need parts or fluids for your Geely Tugella?
Contact ShipMyPart on WhatsApp or request a quote. We deliver across the UAE.